NHTSA-Untersuchungen zu erfassten Modellen

The Office of Defects Investigation (ODI) has received 118 complaints alleging detachment of the upper grille deflector on 2022-2024 model year (MY) GMC Sierra vehicles. 21 of these 118 complaints allege that the upper grille deflector detached after Recall 25V-060 was performed. The complaints allege that the upper grille deflector detaches while driving. In some cases, leading to a cracked winds…

The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompanied by an "Engine Coolant Over Temperature" warning message.  The petition further alleges that afte…

On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” message at start up or while driving. GM shared records regarding several internal investigations for loss of brake assist …

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued R…

The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle directional control. In most cases, there was no advance warning or indication that the suspension failur…

NHTSA is opening this Audit Query (AQ) to investigate NU Car Rentals (NU Car) for compliance with the requirements of the National Traffic and Motor Vehicle Safety Act.The Safety Act requires that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i). NHTSA is in receipt of information that indicates NU Car rented at …

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time …

On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly installed rear coil spring may detach while the vehicle is in motion, creating a road hazard that can increase …

The Office of Defects Investigation (ODI) has received 48 Vehicle Owner Questionnaire (VOQ) reports and some Early Warning Reporting (EWR) field reports alleging intermittent loss of motive power in Model Year (MY) 2020–2022 Honda CR-V Hybrid vehicles.  These incidents are alleged to occur without warning at highway speeds and are accompanied by a flashing check engine light immediately before the…

The Office of Defects Investigation (ODI) has received 6 complaints, and multiple Early Warning Reporting (EWR) field reports alleging inaccurate rear seat belt warning status. These allegations concern both false positive and false negative statuses in model year (MY) 2023-2024 Honda Pilot vehicles manufactured by American Honda Motor Co. (Honda). The complaints state that the rear passenger seat…

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Y…

The Office of Defects Investigations (ODI) is opening a Preliminary Evaluation on 2020 Model Year Jeep Gladiators and Wranglers involving a malfunctioning Instrument Panel Clusters (IPC) resulting in the loss of important vehicle metrics and other status information.  ODI has received 89 Vehicle Owner Questionnaires (VOQs) alleging a complete or partial loss of the IPC display while driving.  The …

The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these crashes sustained serious or fatal injuries that appear linked to the ruptures. Six of those drivers sustained fatal injuri…

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation sy…

The Office of Defects Investigation (ODI) has received nine Vehicle Owners Questionnaires (VOQs) reporting an inability to open doors on Model Year (MY) 2021 Tesla Model Y vehicles. The most commonly reported scenarios involved parents exiting the vehicle after a drive cycle in order to remove a child from the back seat or placing a child in the back seat before starting a drive cycle. In those ev…

The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a stickin…

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to b…

The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline.  The subject engine failures were analyzed as part of a Recall Query (RQ24013).  It was determined…

The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift…

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject …

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehic…

On April 25, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24012) to assess BlueCruise, a partial driving automation system available on certain vehicles manufactured by Ford Motor Company (Ford). NHTSA opened the investigation after the agency received notice of two fatal collisions involving BlueCruise-equipped Ford Mustang Mach-E vehicles. Based on the i…

The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets…

The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures…

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simulta…

On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles.  The reports allege that activation of the AEB system occurs while driving with no a…

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV).  On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023…

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupa…

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect…

The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petiti…

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect alle…

NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of inf…

NHTSA is opening this audit query to investigate whether Healey Brothers Ford, LLC of Beacon, New York, has complied with the requirements of the National Traffic and Motor Vehicle Safety Act. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and noncompliance with Federal Motor Vehicle Safety Standards and in turn that a…

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupt…

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rea…

NHTSA received a defect petition (DP19-001) from the Center for Auto Safety (CAS) on March 21, 2019 alleging that the Automatic Emergency Braking (AEB) system on Model Year (MY) 2017-2018 Nissan Rogue and Rogue Sport vehicles was engaging in cases where there was no obstruction in the path of the vehicle. The CAS petition additionally alleges that, based on Nissan's actions, the manufacturer is aw…

The Office of Defects Investigation (ODI) has completed its review of a Petition dated January 9, 2026, requesting an investigation into the loss of the optional all-wheel drive capability in model year (MY) 2021-2023 Acura TLX and MY 2022-2023 Acura MDX vehicles. The Petition alleges failures in the interfacing splines between the front wheel drive transaxle and the rear wheel drive power take of…

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued R…

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on November 24, 2025, requesting an investigation into the emergency mechanical door release in 2022 Model Year (MY) Tesla Model 3.  The petition alleges that the controls for the emergency mechanical door release are not accessible and clearly identifiable and thus fail to comply with Federal Motor Ve…

On October 28, 2025, the Office of Defects Investigations (ODI) opened PE25018 to investigate complaints of inadvertent deployment of the side curtain and/or side thorax air bags. These complaints concern model year (MY) 2018-2022 Honda Odyssey vehicles manufactured by American Honda Motor Co. (Honda). Honda issued recall 26V227 on April 9, 2026, to address concerns of inadvertent side air bag dep…

The Office of Defects Investigation (ODI) received a petition on August 22, 2025, requesting a defect investigation into an alleged defect of the “underbody shields” on model year (MY) 2020 Ford Explorer vehicles. The petition alleges premature degradation and detachment of the plastic underbody shields, potentially leading to road debris. The petition itself can be reviewed at NHTSA.gov under ODI…

On August 6, 2025, the Office of Defect Investigation (ODI) opened Audit Query (AQ) 25001 to assess the implementation of Kia America, Inc.’s (Kia) remedy program for Safety Recall 25V099, involving incorrectly manufactured piston oil rings which may damage the engine causing a loss of motive power or fire. This AQ was opened in response to consumer complaints alleging of an ineffective remedy, in…

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in so…

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private prope…

On November 22, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around th…

On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine…

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility condit…

On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on it…

On September 6, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24024 to investigate allegations of engine compartment fires in model year 2021-2023 Jeep Wrangler and Gladiator vehicles. Most reports described fires starting on the front passenger side of the engine compartment while the vehicle was turned off, with several originating specifically at the electrohyd…

On August 7, 2024, the Office of Defects Investigation (ODI) opened PE24021 to investigate complaints alleging inadvertent unlatching of seat belts in model year (MY) 2020-2023 Hyundai Palisade vehicles manufactured by Hyundai Motor America. The complaints alleged that, without warning, the seat belts sometimes inadvertently unlatch, increasing the risk of injury due to full loss of seat belt protec…

The Office of Defects Investigation (ODI) opened this investigation to assess allegations of tie rod bending, deformation, or related steering linkage damage in certain 2021 Nissan Rogue vehicles. A bent tie rod can affect wheel alignment and steering geometry, and in some circumstances may result in steering pull, abnormal tire wear, reduced steering precision, difficulty maintaining directional …

On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressu…

On May 16, 2024, the Office of Defects Investigations (ODI) opened Recall Query (RQ) RQ24010 to investigate the remedy and scope of recalls 23V-213 and 23V-312. The affected vehicles by these recalls included model years (MY) 2021 through 2023 Volkswagen ID.4 vehicles. ODI received reports of the vehicle’s doors opening while the vehicle was in motion post recall remedy.  ODI, also, received simil…

On April 25, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24012) to assess BlueCruise, a partial driving automation system available on certain vehicles manufactured by Ford Motor Company (Ford). NHTSA opened the investigation after the agency received notice of two fatal collisions involving BlueCruise-equipped Ford Mustang Mach-E vehicles. Based on the i…

On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with these recalls includes certain MY 2020-2022 Ford Escape vehicles and MY 2021-2023 For…

On April 4, 2024, the Office of Defects Investigations (ODI) opened RQ24006 to investigate American Honda Motor Co.’s (Honda’s) proposed remedy for recall 23V-782 as well as scope of the vehicles involved. Honda issued recall 23V-782 on November 21, 2023, which concerns certain model year (MY) 2023-2024 Honda Accord, Honda Accord Hybrid, and Honda HR-V vehicles. Recall 23V-782 states that the driv…

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehic…

On July 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23014) to investigate instances of loss of electronic power-assisted steering in MY 2023 Tesla Model 3 and MY 2023 Tesla Model Y vehicles manufactured by Tesla, Inc. The complaints allege a sudden and unexpected inability to turn the steering wheel or an increase in effort required to turn the steering w…

On December 13, 2023, the Office of Defects Investigation (ODI) opened PE23-023 to investigate allegations of engine failures leading to loss of motive power in model year (MY) 2021-2023 Nissan Rogue; MY 2019-2021 Nissan Altima; and MY 2019-2021 Infiniti QX50 vehicles. At that time, ODI had received 6 Vehicle Owner Questionnaires (VOQ) and multiple early warning reports, with consumers reporting e…

On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 V…

On November 29, 2023, the Office of Defects Investigation (ODI) opened this Engineering Analysis (EA23003) to assess allegations of momentary increase in steering effort in model years (MY) 2022-2023 Honda Civic, 2023MY Honda CR-V, and 2023MY Acura Integra vehicles (subject vehicles). The complaints received by ODI alleged that the subject vehicles experienced a momentary increase in required steerin…

On November 22, 2023, the Office of Defects Investigation (ODI) opened PE23-021 to investigate instances of seat belt pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints allege hearing a loud, explosion-like sound immediately followed by the seatbelt tightening around the occupant’s torso area. The complaints do n…

On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the abilit…

On August 17, 2023, the Office of Defects Investigations (ODI) opened RQ23-004 to investigate instances of loss of motor power due to overheating high voltage battery contactors in model year (MY) 2021-2022 Ford Mustang Mach-E vehicles (subject vehicles). This Recall Query (RQ) was opened after receiving 12 consumer complaints alleging a high voltage battery main contactor failure in subject vehic…

On July 28, 2023, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-014) after receiving 12 Vehicle Owner Questionnaires (VOQs) reporting loss of steering control in model years (MY) 2023 Tesla Model 3 and Y vehicles. During PE23-014, ODI interviewed complainants, sent an Information Request (IR) letter to Tesla, and convened technical meetings with Tesla that include…

In a letter dated July 2, 2023, Aldelberto A. Cordova (the petitioner) submitted a petition requesting that NHTSA initiate an investigation of an alleged defect within the “ISG 48-volt on-board electrical system,” which resulted in warning light illumination as well as an inability to start the vehicle in a 2023 Mercedes-Benz GLC300. ODI reviewed the petition, complaint data in NHTSA's databases a…

On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditio…

On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged o…

On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to th…

On June 8, 2023, the Office of Defect Investigation (ODI) opened PE23011 to investigate allegations of loss of motor power on model year (MY) 2022 Hyundai Ioniq 5 vehicles. Some consumers reported loss of motor power immediately after a warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charging Control Unit (ICCU) m…

On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls b…

On March 24, 2023, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving 2 consumer complaints alleging the front seat belts had suddenly detached from the outboard lap pretensioner anchor while in motion in model year (MY) 2022-2023 Tesla Model X vehicles. In its June 19, 2023 response to ODI’s May 4, 2023 Information Request letter of the PE, Tesla rep…

On March 17, 2023, The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE23-005) to access the alleged defect of momentary increase in steering effort in model years (MY) 2022 and 2023 Honda Civic vehicles. The complaints report that the momentary increase in steering effort (described as "sticky steering") occurs mostly at highway speeds after driving for a certain amount of …

On March 4, 2023, the Office of Defects Investigation (ODI) opened PE23003 to investigate two reports of steering loss on model year (MY) 2023 Tesla Model Y vehicles due to the detachment of the steering wheel from the steering column while the vehicle was in motion. ODI confirmed from Tesla that in both cases, the vehicles were delivered to the owners missing the retaining bolt (P/N 1036655-00-A)…

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and ele…

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injur…

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23002 to investigate allegations of loss of high beams with no warning and no re-engagement resulting in reduced visibility at night in the 2020 Kia Telluride. The investigation revealed that the halogen bi-function projector beam, used in vehicles built between January 2019 and November of 2019, is composed of one halogen bul…

On August 15, 2022, Hyundai Motor America (Hyundai) filed a safety recall (NHTSA Recall 22V-627) of 122,919 model year (MY) 2020-2021 Hyundai Palisade vehicles produced from April 10, 2019 to November 30, 2020. This recall addressed windshield wipers that may function intermittently or stop functioning when impeded by the accumulation of snow and/or ice at the bottom of the windshield. Intermitten…

On December 2, 2022, the Office of Defects Investigation (ODI) opened PE22-013 to investigate allegations of loss of motive power accompanied by high coolant temperature messages on the dashboard of Model Year 2019-2020 Jeep Compass vehicles. At the time this investigation was opened, ODI was aware of fifteen Vehicle Owner Questionnaires (VOQs) for Model Year (MY) 2019-2020 Jeep Compass vehicles a…

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. T…

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints i…

On August 8, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) based on 3 incidents alleging front seat belt pretensioners that may rupture during deployment, on model year (MY) 2020-2022 of various Hyundai and Kia Models, resulting in 3 injuries (note: one incident occurred outside the U.S. and its territories).Between October 2021 and March 2023, Hyundai and Kia have …

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysl…

The Office of Defects Investigation (ODI) received a petition dated March 16, 2022, requesting an investigation regarding allegations of defective intake valves in model year (MY) 2021 Ford Bronco vehicles equipped with the 2.7L Eco-boost (“Nano”) engines.  The petitioner alleged these vehicles are experiencing loss of motive power at any highway speeds with no-restart as a result of catastrophic …

The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support th…

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject …

The Office of Defects Investigation (ODI) received three petitions on March 17, March 18, and March 29, 2022, which requested a defect investigation into an alleged defect of the valves on model year (MY) 2021 Ford Bronco vehicles equipped with the 2.7L Eco-boost engines. The petitioners alleged that MY 2021 Ford Broncos vehicles are experiencing loss of motive power at highway speeds with no-rest…

On April 10, 2022, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving 5 consumer complaints alleging the Power Sliding Doors (PSD) auto-reverse function failed to work properly in the model year (MY) 2022 Kia Carnival minivan vehicles.At that time, ODI was aware of 3 complaints alleging injuries to consumer?s arm, hand or shoulder caused by the closin…

On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda Accord vehicles.  The reports allege that activation of the AEB system occurs while driving with no a…

On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesla. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cru…

The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE21-023) on December 21, 2021, to evaluate the driver distraction potential and use frequency / circumstances of in-vehicle game-play functionality referred to as ?Passenger Play? in certain model year (MY) 2017-2022 Tesla Model 3, S, X, and Y vehicles. Distracted driving can result in an increased risk of a crash. PE21-023 …

On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the driving task) available in Tesla vehicles. The investigation opening was motivated by an accumulatio…

On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models…

The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on rep…

On January 8, 2021, after ongoing review with Mercedes Benz, the National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation (ODI) opened PE21-001 to assess allegations of front roof panel detachments while driving at highway speeds in certain 2015 Mercedes-Benz (Mercedes) C-Class vehicles.The subject front roof panel is a stationary panel composed of polycarbonate and i…

On November 20, 2020, the Office of Defects Investigation (ODI) opened Engineering Analysis (EA) 20-003 to investigate incidents of media control unit (MCU) failures resulting in loss of rearview camera in model year (MY) 2012-18 Tesla Model S and model year (MY) 2016-2018 Tesla Model X vehicles equipped with the NVIDIA Tegra 3 processor with an integrated 8GB eMMC NAND flash memory device. During…

In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caug…

On June 22, 2020, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE20-010 to investigate incidents of media control unit (MCU) failures resulting in loss of rearview camera in model year (MY) 2012-2015 Tesla Model S vehicles equipped with the NVIDIA Tegra 3 processor with an integrated 8GB eMMC NAND flash memory device. EMMC NAND flash devices have a finite lifespan based…

On December 19, 2019, NHTSA received a petition from Mr. Brian Sparks requesting that the Agency recall all [Tesla] Model S, Model X, and Model 3 vehicles produced from 2013 to the present due to sudden unintended acceleration (SUA). In his petition and follow-up submissions, the petitioner identified a total of 232 non-duplicative complaints to NHTSA, including 203 reporting crashes. On January 1…

In a letter dated September 17, 2019, Mr. Edward Chen petitioned the NHTSA to initiate a defect investigation of certain Tesla Model S and Model X vehicles that received revised battery management software in one or more over-the-air (OTA) updates from Tesla, beginning in May 2019. The petitioner bases his request on vehicle fires that took place worldwide and OTA software updates Tesla made to th…

On September 16, 2019, the Office of Defects Investigation (ODI) granted Defect Petition DP18-004 and opened Preliminary Evaluation PE19-012 to investigate allegations of deficient frame welds and their potential safety related effects on 2018-2019 Jeep Wranglers. Due to a previous steering related recall that was caused by a misaligned weld on the front track bar (NHTSA Recall No. 18V-675), ODI d…

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small …

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic wit…

The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as e…

On July 17, 2019, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 19-008 after receiving three Vehicle Owner Questionnaire (VOQ) reports alleging the driver's side seat belt buckle separated from the seat frame, rendering the seat belt non-functional. The VOQs involved model year (MY) 2015 and 2016 Jeep Wrangler (JK platform) that were configured for right-hand dri…

On July 29, 2019, the Office of Defects Investigation (ODI) opened EA19002 to investigate instances of alleged rear lower control arm failures in 2013-2018 Nissan Altima and 2016-2018 Nissan Maxima vehicles. At the time the investigation was opened ODI had 91 consumer complaints alleging rear lower control arm failures in the subject vehicles.ODI was concerned about these complaints because many o…

The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect.  During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicle…

NHTSA received a letter from the Center for Auto Safety (CAS) on March 21, 2019 alleging that the Automatic Emergency Braking (AEB) system on Model Year (MY) 2017-2018 Nissan Rogue and Rogue Sport vehicles was engaging in cases where there was no obstruction in the path of the vehicle. The CAS petition additionally alleged that, based on Nissan's actions, the manufacturer was aware of the issue du…

PE18-013 was opened on December 1, 2018, with 4 complaints to ODI alleging incidents of the lower control arm fracturing at a connection point to the vehicle chassis due to corrosion. ODI has received an additional 87 complaints since the PE was opened. During PE18-013, Nissan indicated model years 2013-2018 shared a common rear lower control arm design. Nissan provided complaint and warranty data…

In a letter received on October 24, 2018, a citizen petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into frame weld deficiencies on model year (MY) 2018 'JL' Jeep Wrangler vehicles. The petitioner described a broad list of frame weld deficiencies, including porous welds, excessive slag, lack of weld penetration, over penetration of we…

On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investig…

In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA R…

In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in…